Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall 97V080000: Unexpected Air Bag Deployment
- Recall - Airbag Control Module
- Overview
- Service Procedure For Neon (PL) Vehicles:
- Service Procedure For Dakota (AN) Vehicles:
- Service Procedure For Wrangler (TJ) Vehicles:
- Service Procedure For Grand Cherokee (ZJ) Vehicles:
- Service Procedure For Viper GTS Coupe (SR) Vehicles:
- Completion Reporting and Reimbursement / Parts Return
- Vehicle Not Available
- Dealer Service Instructions
- Owner Letter
- Recall - Passenger Air Bag Safety
- Customer Interest
- Drive Belt - Momentary Loss of Power Steering Assist
- Front Brakes - Squeal or Creep/Groan
- Blower Motor - Inoperative In Freezing Temps
- Steering Gear - Whistle/Hiss On Right Turns
- Front Suspension - Popping/Creaking Noises
- Front Foot Well - Creak/Rattle on Bumps
- Front Suspension - Popping Noise On Bumps
- Roof Rail Weatherstrip - Water Leaks into Vehicle
- Sunroof - Ratcheting Noise When Opening Or Closing
- Steering Wheel/Steering Column - Clunking Or Rattle
- Rear Brakes - Howl During Low Speed Stop
- PCM - Stumble/Rpm Flare/Low Performance With A/C ON
- I/M Testing - OBDII CARB Readiness Monitor Information
- Interior Lamps - Improper Operation
- Tachometer - Fluctuates and/or Bounces
- Cooling System - Fan ON Continuously/Overheats
- Steering/Suspension - Smooth Road Vibration
- Black Plastic Body Components - Chalky Residue
- Door Glass - Scratches
- Wipers/Washers - Wipers Smear or Streak Windshield
- Center Console Latch - Broken
- Wheel Covers - Noisy/Missing/Loose
- Paint - Surface Fogging or Whitening
- RKE Transmitter - Premature Battery Failure
- A/C Evaporator - Emits Odors
- Evaporator Drain - Water Leaks Into Interior
- Sunroof Shade - Rattles In Full Open Position
- Power Steering System - Noise in Cold Temperatures
- A/C - Musty Odors When Hot/Humid
- Superceded Bulletins
- 23-08-00B - 11/24/00
- Roof Rail Weatherstrip - Water Drips Into Vehicle
- Paint - Milky/Fogging Over Time
- Paint - Fogging/Milky Appearance
- Outside Rearview Mirror Glass - Replacement
- Emergency Trunk Release - Parts Identification
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- A/C Compressor - Bump on Engagement
- Blower Motor - Does Not Operate In Extreme Cold
- Suspension - Popping Noise on Bumps
- Steering Wheel/Column - Clunking/Rattling
- Front Suspension - Popping Noise
- Electrical - Wire Splice Procedure Revision
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- Leak Detection Pump - Dealer Test Mode
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- PCM - Flash Programming Failure Recovery
- Cooling System - Overheats/Fan ON Continuously
- Head Gasket - Improved Design/Installation
- A/T - Fluid Usage
- A/C - Musty Odors When Hot or Humid
- Front Suspension - Popping/Creaking Noise
- Front Suspension - Popping Noise When Turning
- Rear Brakes - Howling During Low Speed Stop
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Revisions/Updates
- Brakes - Noise Explanation
- Instrument Cluster - Part Specification
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Drive Belt - Momentary Loss of Power Steering Assist
- Front Brakes - Squeal or Creep/Groan
- A/C Compressor - Bump Feel On Compressor Cycling
- Blower Motor - Inoperative In Freezing Temps
- A/C , Heater - Odors/Defroster Will Not Clear Glass
- Alignment and Suspension - Specifications and Adjustment
- Steering Gear - Whistle/Hiss On Right Turns
- Aluminum Engine - Gasket Surface Preparation
- Front Suspension - Popping/Creaking Noises
- Front Foot Well - Creak/Rattle on Bumps
- Front Suspension - Popping Noise On Bumps
- Tire and Wheel - Runout
- Rear Bumper Fascia - Production Modifications
- Roof Rail Weatherstrip - Water Leaks into Vehicle
- Sunroof - Ratcheting Noise When Opening Or Closing
- Steering Wheel/Steering Column - Clunking Or Rattle
- Fuel System - Injector Circuit Test Revisions
- Cam/Crank Sensor - No Start Diagnostics
- Cam Position Sensor - Oil Seepage Diagnosis
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Brakes - Teves Mark IV/Teves Mark 20 ABS Revisions
- Rear Brakes - Howl During Low Speed Stop
- PCM - Symptomless Misfire DTC's/MIL ON
- PCM - Stumble/Rpm Flare/Low Performance With A/C ON
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- Interior Lamps - Improper Operation
- Radio Communication Equipment - Recommendations
- Interior - Seat Belt Cinch Bar Service
- Recall 97V080000: Unexpected Air Bag Deployment
- Airbag/Clock Spring - Service
- Recall - Airbag Control Module
- Overview
- Service Procedure For Neon (PL) Vehicles:
- Service Procedure For Dakota (AN) Vehicles:
- Service Procedure For Wrangler (TJ) Vehicles:
- Service Procedure For Grand Cherokee (ZJ) Vehicles:
- Service Procedure For Viper GTS Coupe (SR) Vehicles:
- Completion Reporting and Reimbursement / Parts Return
- Vehicle Not Available
- Dealer Service Instructions
- Owner Letter
- Tachometer - Fluctuates and/or Bounces
- Cooling System - Fan ON Continuously/Overheats
- Recall- Radiator Fan Relay
- Recall - Radiator Fan Relay
- Cooling System - Cooling Fan Relay Pin-Out Revisions
- Multi Layer Steel Head Gasket - Installation Procedures
- ABS/TCS - Diagnostic Test Revisions
- Brakes - Teves Mark IVG and Mark 20 ABS Revisions
- Brakes - Kelsey Hayes ABS Manual Revisions
- Brakes - Kelsey-Hayes ABS System Diagnostic Revisions
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Steering/Suspension - Smooth Road Vibration
- Black Plastic Body Components - Chalky Residue
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Leak Detection Pump - Monitor Test
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - Crankshaft Timing Re-Learn Procedure
- Electrical - PDC/Fuse Block/Connector Revisions
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Interior - Door Trim Panel Service Procedure Revisions
- Door Glass - Scratches
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- Competition Package Front Fascia - Information
- Engine - Coolant Recommendations
- Center Console Latch - Broken
- Wheel Covers - Noisy/Missing/Loose
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Front Cam Seal Retainer - New Design
- Wiring - Revised Splicing Procedure
- Radio - Poor AM Reception/Static
- Electrical - Wiring Diagram Connector Pinout Revisions
- Paint - Surface Fogging or Whitening
- Paint - Fallout Damage Repair
- Emergency Trunk Release - Availability
- RKE Transmitter - Premature Battery Failure
- A/C Evaporator - Emits Odors
- Proportioning Valve - Pressure Adapter Tool Revision
- Evaporator Drain - Water Leaks Into Interior
- Sunroof Shade - Rattles In Full Open Position
- Power Steering System - Noise in Cold Temperatures
- Steering - Power Steering Fluid Usage
- EVAP System - Leak Detection Pump Misdiagnosis
- Engine - High Driveability Index Fuels
- Steering/Suspension - Alignment Specifications Revisions
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T Pan Gasket - Reusable Design/Installation
- A/C - Musty Odors When Hot/Humid
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process