Body - Front/Rear Door Window Binds/Operates Slowly
TSB 09-22-911/16/09
DOOR GLASS - SLOW CLOSE/BINDS WHEN GOING
UP/WINDNOISE OR TOP WINDOW RUN
FOLDED/LOOSE
FORD:
2009 Focus
2010 Focus
ISSUE
Some 2009-2010 Focus vehicles may exhibit wind noise from the front or rear door glass which may be the result of the window glass binding, stalling or being dislodged from the glass top run when closing. This may be caused by the door glass not entering the glass top run properly.
ACTION
Follow the service procedure to correct the condition.
SERVICE PROCEDURE
1. Inspect the door glass top run(s) for damage. Is any damage present?
a. Yes - Perform the following: Perform Steps (1-4) as required for each suspect window run.
(1) Remove damaged door glass top run. Refer to Workshop Manual (WSM), Section 501-11.
(2) Apply Motorcraft(R) Trim and Weatherstrip Adhesive, or equivalent to new glass top run in the areas indicated. (Figure 1)
(3) Install new glass top run per WSM, Section 501-11.
(4) Place window in full closed position; do not operate window for one hour.
b. No - Proceed to Step 2. Perform Steps 2-5 as required for each suspect window run.
2. Pull the door glass top run away from the upper channel.
3. Apply Motorcraft(R) Trim and Weatherstrip Adhesive, or equivalent to the areas indicated. (Figure 1)
4. Install window run into upper channel.
5. Place window in full closed position; do not operate window for one hour.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
092209A 2009 Focus: Replace The 0.8 Hr.
Door Glass Top Run One
(1) Front Door This Labor
Operation Can Be Claimed
With C, D, E, G And H
(Do Not Use With Any
Labor Operations Outside
Of This Article)
092209B 2009 Focus: Replace The 1.6 Hrs.
Door Glass Top Run On
Two (2) Front Doors This
Labor Operation Can Be
Claimed With C, D, G And
H (Do Not Use With Any
Labor Operations Outside
Of This Article)
092209C 2009 Focus: Replace The 0.6 Hr.
Door Glass Top Run One
(1) Rear Door This Labor
Operation Can Be Claimed
With A, B, E, F And G (Do
Not Use With Any Labor
Operations Outside Of This
Article)
092209D 2009 Focus: Replace The 1.2 Hrs.
Door Glass Top Run On
Two (2) Rear Doors This
Labor Operation Can Be
Claimed With A, B, E, F
And G (Do Not Use With
Any Labor Operations
Outside Of This Article)
092209E 2009 Focus: Apply 0.3 Hr.
Adhesive To The Door
Glass Top Run One (1)
Front Door This Labor
Operation Can Be Claimed
With A, C, D, G And H
(Do Not Use With Any
Labor Operations Outside
Of This Article)
092209F 2009 Focus: Apply 0.4 Hr.
Adhesive To The Door
Glass Top Run On Two
(2) Front Doors This Labor
Operation Can Be Claimed
With C, D, G And H (Do
Not Use With Any Labor
Operations Outside Of This
Article)
092209G 2009 Focus: Apply 0.3 Hr.
Adhesive To The Door
Glass Top Run One (1)
Rear Door This Labor
Operation Can Be Claimed
With A, B, C, E, F And H
(Do Not Use With Any
Labor Operations Outside
Of This Article)
092209H 2009 Focus: Apply 0.4 Hr.
Adhesive To The Door
Glass Top Run On Two
(2) Rear Doors This Labor
Operation Can Be Claimed
With A, B, E, F And H (Do
Not Use With Any Labor
Operations Outside Of This
Article)
DEALER CODING
CONDITION
BASIC PART NO. CODE
7021510 07
Disclaimer