Interior - Headliner Loose At Moonroof Opening

11-006

February 9, 2011

Applies To:
2009-10 CR-V - ALL VINs beginning with 3CZ or 5J6

Headliner Fabric Is Loose Around the Moonroof Opening

SYMPTOM

The headliner fabric is detached from the headliner around the moonroof opening.

PROBABLE CAUSE

The headliner fabric has lost its adhesion.

CORRECTIVE ACTION

Reattach the headliner fabric to the plastic bracket on the headliner.

REQUIRED MATERIALS

Wool Felt: P/N 06993-SA5-000
(One roll repairs 39 vehicles)

TOOL INFORMATION

KTC Trim Tool Set: T/N SOJAT02014

WARRANTY CLAIM INFORMATION

The normal warranty applies.

Operation Number: 8420A4

Flat Rate Time: 0.2 hour

Failed Part: P/N 83200-SWA-A52ZA

Defect Code: 07404

Symptom Code: 02502

Skill Level: Repair Technician

REPAIR PROCEDURE

1. Open the sunshade.





2. Release the headliner from the front edge of the moonroof opening by detaching the clips and the hook and loop locks along the sides and back. If the headliner fabric is detached at the rear of the moonroof opening, remove the ceiling light.

3. Slide a trim tool between the headliner and moonroof opening near the area where the fabric is loose.





NOTE:
You may need to use a trim tool on either side of the affected area to give yourself more room to work.

4. Cut a 30 mm x 75 mm piece of wool felt.





5. Fold the headliner fabric over the moonroof opening edge, and center the wool felt over the edge of the headliner fabric where it meets onto the plastic headliner ring. Press down firmly on the wool felt.

6. Reattach the headliner clips and the hook and loop locks to the moonroof frame, then reinstall the ceiling light if removed.





Disclaimer