Interior - Auxiliary Power Socket Comes Out Of Console

09-048

September 15, 2009

*Applies To:
2009 Pilot - ALL
2010 Pilot 2WD - From VIN 5FNYF3...AB000001 thru 5FNYF3...AB001437
2010 Pilot 4WD - From VIN 5FNYF4...AB000001 thru 5FNYF4...AB001205*

Accessory Power Socket Comes Out of the Center Console Rear Trim (Supersedes 09-048, dated July 10, 2009, to revise the information marked by asterisks)

*REVISION SUMMARY

In Applies To, all 2009 Pilots and some 2010 Pilots are now included.*

SYMPTOM

When you pull out an accessory's plug from the accessory power socket on the center console rear trim, the power socket comes out with the plug.

PROBABLE CAUSE

The curved shape of the center console rear trim does not provide a good fit for the accessory power socket.

CORRECTIVE ACTION

Replace the center console rear trim.

PARTS INFORMATION

Center Console Rear Trim:

Baltic Blue (B167L) - P/N 83419-SZA-A01ZA, H/C 8890832

Graphite Black (NH167L) - P/N 83419-SZA-A01ZB, H/C 8890840

QP Light Warm Gray (NH686L) - P/N 83419-SZA-A01ZC, H/C 8890857

TU Light Beige (YR309L) - P/N 83419-SZA-A01ZD, H/C 8890865

WARRANTY CLAIM INFORMATION

In warranty:
The normal warranty applies.

Operation Number: 8411G7

Flat Rate Time: 0.4 hour

Failed Part: P/N 83419-SZA-A01ZA
H/C 8890832

Defect Code: 06201

Symptom Code: 00101

Skill Level: Repair Technician

Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.

REPAIR PROCEDURE

NOTE:
Be careful not to scratch the center console or any other trim parts.

1. Remove the center console rear trim:

^ Pull the top of the trim to detach the upper clips.

^ Continue pulling the sides of the trim to release the side clips.

^ Disconnect the 8P connector, then remove the rear trim from the center console.

2. Remove these parts from the rear trim, and install them on the new rear trim:

NOTE:
Not all vehicles are equipped with all of the parts listed below.





^ Rear control panel harness

^ Upper and lower ducts (six screws)





^ Right and left vents and vent trim (eight screws)





^ Rear A/C control panel





^ Auxiliary jack assembly





^ Rear trim cover

^ Accessory power socket and housing

3. Install the new rear trim, making sure that all parts are correctly installed and all trim clips are firmly seated.