Interior - Auxiliary Power Socket Comes Out Of Console
09-048September 15, 2009
*Applies To:
2009 Pilot - ALL
2010 Pilot 2WD - From VIN 5FNYF3...AB000001 thru 5FNYF3...AB001437
2010 Pilot 4WD - From VIN 5FNYF4...AB000001 thru 5FNYF4...AB001205*
Accessory Power Socket Comes Out of the Center Console Rear Trim (Supersedes 09-048, dated July 10, 2009, to revise the information marked by asterisks)
*REVISION SUMMARY
In Applies To, all 2009 Pilots and some 2010 Pilots are now included.*
SYMPTOM
When you pull out an accessory's plug from the accessory power socket on the center console rear trim, the power socket comes out with the plug.
PROBABLE CAUSE
The curved shape of the center console rear trim does not provide a good fit for the accessory power socket.
CORRECTIVE ACTION
Replace the center console rear trim.
PARTS INFORMATION
Center Console Rear Trim:
Baltic Blue (B167L) - P/N 83419-SZA-A01ZA, H/C 8890832
Graphite Black (NH167L) - P/N 83419-SZA-A01ZB, H/C 8890840
QP Light Warm Gray (NH686L) - P/N 83419-SZA-A01ZC, H/C 8890857
TU Light Beige (YR309L) - P/N 83419-SZA-A01ZD, H/C 8890865
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Operation Number: 8411G7
Flat Rate Time: 0.4 hour
Failed Part: P/N 83419-SZA-A01ZA
H/C 8890832
Defect Code: 06201
Symptom Code: 00101
Skill Level: Repair Technician
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.
REPAIR PROCEDURE
NOTE:
Be careful not to scratch the center console or any other trim parts.
1. Remove the center console rear trim:
^ Pull the top of the trim to detach the upper clips.
^ Continue pulling the sides of the trim to release the side clips.
^ Disconnect the 8P connector, then remove the rear trim from the center console.
2. Remove these parts from the rear trim, and install them on the new rear trim:
NOTE:
Not all vehicles are equipped with all of the parts listed below.
^ Rear control panel harness
^ Upper and lower ducts (six screws)
^ Right and left vents and vent trim (eight screws)
^ Rear A/C control panel
^ Auxiliary jack assembly
^ Rear trim cover
^ Accessory power socket and housing
3. Install the new rear trim, making sure that all parts are correctly installed and all trim clips are firmly seated.