Powertrain Management: Technical Service Bulletins

• Recalls
  • Recall - Fuel Rail O-Rings and Reinforcements
    • Overview
    • Service Procedure
      • A. Leak Test and Remove the Fuel Rail
      • B. Reinforce the Fuel Outlet Rail
      • C. Replace the Fuel Outlet Rail
      • D. Assemble and Install Fuel Rail
    • Owner Letter
  • Recall 98V184000: Fuel Rail/Injector O-Rings Leak
• Customer Interest
  • A/T - 41TE/AE 42LE Delayed Gear Engagement
    • Overview
    • Symptom/Condition
    • Diagnosis
    • Item 1 DTC 35 Loss of Prime
    • Item 2 L - R Inner and Outer Seals
    • Item 3 UD Inner Lip Seal
    • Item 4 General Seal Statement
    • Item 5 Measuring # 1 Check Ball Clearance
    • Item 6 PRNDL Switch (Non TRS)
    • Item 7 Output Speed Sensor
  • PCM - Cold Start Idle/Sags/Hesitations
    • Overview
    • Repair Procedure
  • I/M Testing - OBDII CARB Readiness Monitor Information
    • Overview
    • Repair Procedure
  • A/C Compressor - Growl Noise/Hard Air Cleaner Access
  • Speed Sensor - Intermittent Loss of Cruise Control
  • Fuel Tank - Slow To Fill Or Will Only Fill To Half Full
• By Symptom
  • Customer Interest
    • A/T - 41TE/AE 42LE Delayed Gear Engagement
      • Overview
      • Symptom/Condition
      • Diagnosis
      • Item 1 DTC 35 Loss of Prime
      • Item 2 L - R Inner and Outer Seals
      • Item 3 UD Inner Lip Seal
      • Item 4 General Seal Statement
      • Item 5 Measuring # 1 Check Ball Clearance
      • Item 6 PRNDL Switch (Non TRS)
      • Item 7 Output Speed Sensor
    • PCM - Cold Start Idle/Sags/Hesitations
      • Overview
      • Repair Procedure
    • I/M Testing - OBDII CARB Readiness Monitor Information
      • Overview
      • Repair Procedure
    • A/C Compressor - Growl Noise/Hard Air Cleaner Access
    • Speed Sensor - Intermittent Loss of Cruise Control
    • Fuel Tank - Slow To Fill Or Will Only Fill To Half Full
  • Driveability
    • PCM - Cold Start Idle/Sags/Hesitations
      • Overview
      • Repair Procedure
  • Erratic Operation
    • Speed Sensor - Intermittent Loss of Cruise Control
  • Leaks
    • Recall 98V184000: Fuel Rail/Injector O-Rings Leak
  • No shift/Incorrect gear engagement
    • A/T - 41TE/AE 42LE Delayed Gear Engagement
      • Overview
      • Symptom/Condition
      • Diagnosis
      • Item 1 DTC 35 Loss of Prime
      • Item 2 L - R Inner and Outer Seals
      • Item 3 UD Inner Lip Seal
      • Item 4 General Seal Statement
      • Item 5 Measuring # 1 Check Ball Clearance
      • Item 6 PRNDL Switch (Non TRS)
      • Item 7 Output Speed Sensor
  • Noise
    • A/C Compressor - Growl Noise/Hard Air Cleaner Access
  • Poor performance
    • Engine - High Driveability Index Fuels
  • Recalls
    • Recall - Fuel Rail O-Rings and Reinforcements
      • Overview
      • Service Procedure
        • A. Leak Test and Remove the Fuel Rail
        • B. Reinforce the Fuel Outlet Rail
        • C. Replace the Fuel Outlet Rail
        • D. Assemble and Install Fuel Rail
      • Owner Letter
    • Recall 98V184000: Fuel Rail/Injector O-Rings Leak
• All Technical Service Bulletins
  • Engine Controls - Co-Pilot Support/Correct Cable Usage
  • A/T - 41TE/AE 42LE Delayed Gear Engagement
    • Overview
    • Symptom/Condition
    • Diagnosis
    • Item 1 DTC 35 Loss of Prime
    • Item 2 L - R Inner and Outer Seals
    • Item 3 UD Inner Lip Seal
    • Item 4 General Seal Statement
    • Item 5 Measuring # 1 Check Ball Clearance
    • Item 6 PRNDL Switch (Non TRS)
    • Item 7 Output Speed Sensor
  • Fuel System - Injector Circuit Test Revisions
  • PCM - Cold Start Idle/Sags/Hesitations
    • Overview
    • Repair Procedure
  • I/M Testing - OBDII CARB Readiness Monitor Information
    • Overview
    • Repair Procedure
  • Engine Controls - Flash Programming Failure Recovery
    • Overview
    • Connected/Disconnected Flash Mode Using TechCONNECT
    • Pay Attention While Performing Flash Reprogram Procedures
    • Error Messages
    • Enhanced and Original Abort Recovery
    • Enhanced Abort Recovery Screens
    • Original Abort Recovery Screen
    • Programmable Modules
    • Powertrain Modules - Engine and Transmission
  • Recall - Fuel Rail O-Rings and Reinforcements
    • Overview
    • Service Procedure
      • A. Leak Test and Remove the Fuel Rail
      • B. Reinforce the Fuel Outlet Rail
      • C. Replace the Fuel Outlet Rail
      • D. Assemble and Install Fuel Rail
    • Owner Letter
  • Recall 98V184000: Fuel Rail/Injector O-Rings Leak
  • Air Induction - Air Filter Service Procedure Update
  • A/C Compressor - Growl Noise/Hard Air Cleaner Access
  • Leak Detection Pump - Monitor Test
  • Auto Computers - Y2K Effects
  • Generic Scan Tool - Reference Information
    • Overview
    • Quick Reference
    • 1. Powertrain Diagnostic Data
    • 2. Powertrain Freeze Frame
    • 3. Emission Related DTCs
    • 4. Clear/Reset DTCs
    • 5. O2 Monitoring Results
    • 6. Last Monitor Results
    • 7. 1 Trip Failures
    • 8. On Board System Test
    • 9. Vehicle Information
    • Appendix A, B, C and D Information
  • Transmission Range Sensor - Production Change
  • Speed Sensor - Intermittent Loss of Cruise Control
  • Fuel Tank - Slow To Fill Or Will Only Fill To Half Full
  • EVAP System - Leak Detection Pump Misdiagnosis
  • Engine - High Driveability Index Fuels