A/T - MIL ON/DTC P3009 Or P0AA6/Info Codes 526/613

T-SB-0306-08

Rev1

October 3, 2008

MIL "ON" DTC P3009 or POAA6, Information Codes 526 & 613

Service Category
Engine/Hybrid System

Section
Hybrid/Battery Control System

Market
USA





Applicability

TSB REVISION NOTICE

April 22, 2010 Rev1:

^ Applicable Warranty has been updated in the Warranty Information section. Any previous printed versions of this service bulletin should be discarded.

TSB SUPERSESSION NOTICE

The information contained in this TSB supersedes TSB No. EG045-06.

^ Applicability has been updated to include 2008 model year vehicles.

^ VINs have been updated in the Production Change Information table.

^ The Applicable Warranty has been updated in the Warranty Information section.

^ TIS Techstream has replaced the Toyota Diagnostic Tester in Required Tools & Materials.

TSB No. EG045-06 is Obsolete and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before proceeding.

Introduction

Some 2004 - 2008 model year Prius vehicles may exhibit a MIL "ON" condition with DTC P3009 or P0AA6 with information codes 526 and 613. The transaxle assembly has been improved to address this condition.

NOTE

This TSB applies ONLY if BOTH information codes 526 AND 613 are present.

Production Change Information





This TSB applies to vehicles produced BEFORE the Production Change Effective VINs shown.





Warranty Information

APPLICABLE WARRANTY

^ This repair is covered under the Toyota Powertrain Warranty. This warranty is in effect for 60 months or 60,000 miles, whichever occurs first, from the vehicle's in-service date.

^ Warranty application is limited to occurrence of the specified condition described in this bulletin.





Required Tools & Equipment

Additional TIS Techstream or Techstream Lite units may be ordered by calling Approved Dealer Equipment (ADE).





Parts Information

Repair Procedure

Remove and replace the hybrid vehicle transaxle assembly.

Refer to the Technical Information System (TIS) applicable model year Prius Repair Manual:

^ 2004 / 2006 Prius:
Drivetrain - Hybrid Transmission/Transaxle - "Hybrid Vehicle Transaxle Assy: Replacement"

^ 2006 / 2007 / 2008 Prius:
Drivetrain - Hybrid Transmission/Transaxle - "Hybrid Transmission/Transaxle: Hybrid Vehicle Transaxle: Removal"

^ 2006 / 2007 / 2008 Prius:
Drivetrain - Hybrid Transmission/Transaxle - "Hybrid Transmission/Transaxle: Hybrid Vehicle Transaxle: Installation"