Installation

SLIDING ROOF / CONVERTIBLE: SLIDING ROOF HOUSING: INSTALLATION

INSTALLATION

1. INSTALL SLIDING ROOF WEATHERSTRIP
(a) Install the sliding roof weatherstrip.
2. INSTALL SLIDING ROOF HOUSING SUB-ASSEMBLY
(a) Install the sliding roof housing sub-assembly with the 8 bolts and 7 nuts.
Torque: 5.5 Nm (56 kgf-cm, 49 in-lbf)









(b) Engage the claw.
(c) Install the room light bracket with the nut.
Torque: 5.5 Nm (56 kgf-cm, 49 in-lbf)
(d) Connect the 4 sliding roof drain hoses so that each mark faces downward.




NOTE: Be sure to install the drain hoses properly to prevent entry of water.

3. INSTALL SLIDING ROOF GLASS SUB-ASSEMBLY
(a) Using a T25 "TORX" socket wrench, temporarily install the sliding roof glass sub-assembly with the 4 screws.









(b) Perform a level check.
(1) Check the difference in level for "a" between the roof panel and the upper surface of the weatherstrip when the sliding roof glass is fully closed.

Standard





HINT: "+" represents the condition that the glass is above the panel level. "-" represents the condition that the glass is below the panel level.





(c) Perform a gap check.
(1) Check the gap between the roof panel and roof glass.
NOTE: The gap must be even all around.

(d) After adjusting the sliding roof glass, using a T25 "TORX" socket wrench, install the sliding roof glass sub-assembly with the 4 screws.
Torque: 4.0 Nm (41 kgf-cm, 35 in-lbf)
4. INSPECT FOR WATER LEAK
(a) After adjusting the sliding roof glass sub-assembly, inspect for water leaks.
(b) If there are any leaks, readjust the sliding roof glass sub-assembly.
5. INSTALL SLIDING ROOF SIDE GARNISH LH





(a) Engage the 5 claws to install the sliding roof side garnish LH.
6. INSTALL SLIDING ROOF SIDE GARNISH RH
HINT: Use the same procedure for the RH side and the LH side.

7. INSTALL CURTAIN SHIELD AIRBAG ASSEMBLY LH (w/ Curtain Shield Airbag) Installation
8. INSTALL CURTAIN SHIELD AIRBAG ASSEMBLY RH (w/ Curtain Shield Airbag)
HINT: Use the same procedure for the RH side and the LH side.

9. INSTALL REAR SIDE RAIL SPACER LH (w/o Curtain Shield Airbag)





(a) Engage the 5 claws to install the rear side rail spacer LH.
10. INSTALL FRONT SIDE RAIL SPACER LH (w/o Curtain Shield Airbag)





(a) Engage the 5 claws to install the rear side rail spacer LH.
11. INSTALL REAR SIDE RAIL SPACER RH (w/o Curtain Shield Airbag)
HINT: Use the same procedure for the RH side and the LH side.

12. INSTALL FRONT SIDE RAIL SPACER RH (w/o Curtain Shield Airbag)
HINT: Use the same procedure for the RH side and the LH side.

13. INSTALL ROOF HEADLINING ASSEMBLY (w/ Sliding Roof) Installation
14. INSTALL VISOR HOLDER Installation
15. INSTALL REAR ASSIST GRIP ASSEMBLY Installation
16. INSTALL FRONT ASSIST GRIP SUB-ASSEMBLY (w/o Curtain Shield Airbag) Installation
17. INSTALL FRONT ASSIST GRIP SUB-ASSEMBLY (w/ Curtain Shield Airbag) Installation
18. INSTALL VISOR ASSEMBLY LH Installation
19. INSTALL VISOR ASSEMBLY RH Installation
20. INSTALL SUN ROOF OPENING TRIM MOULDING Installation
21. INSTALL NO. 2 ROOM LIGHT ASSEMBLY Installation
22. INSTALL NO. 1 ROOM LIGHT ASSEMBLY Installation
23. INSTALL MAP LIGHT ASSEMBLY Installation
24. INSTALL INNER REAR VIEW MIRROR COVER (w/ EC Mirror) Installation
25. INSTALL QUARTER PILLAR GARNISH LH Installation
26. INSTALL ROOF SIDE INNER GARNISH LH Installation
27. INSTALL SIDE DECK TRIM PANEL ASSEMBLY LH Installation
28. INSTALL REAR COMBINATION LIGHT SERVICE COVER LH Installation
29. INSTALL NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (for LH Side) Installation
30. INSTALL LUGGAGE HOLD BELT STRIKER ASSEMBLY (for LH Side) Installation
31. CONNECT REAR SEAT 3 POINT TYPE BELT ASSEMBLY LH Installation
32. INSTALL REAR SEAT SIDE GARNISH LH Installation
33. INSTALL REAR SEATBACK HINGE SUB-ASSEMBLY (for LH Side) Installation
34. INSTALL QUARTER PILLAR GARNISH RH Installation
35. INSTALL ROOF SIDE INNER GARNISH RH Installation
36. INSTALL SIDE DECK TRIM PANEL ASSEMBLY RH (w/o Woofer) Installation
37. INSTALL SIDE DECK TRIM PANEL ASSEMBLY RH (w/ Woofer) Installation
38. INSTALL REAR COMBINATION LIGHT SERVICE COVER RH (w/ Woofer) Installation
39. INSTALL NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (for RH Side) Installation
40. INSTALL LUGGAGE HOLD BELT STRIKER ASSEMBLY (for RH Side) Installation
41. CONNECT REAR SEAT 3 POINT TYPE BELT ASSEMBLY RH Installation
42. INSTALL REAR SEAT SIDE GARNISH RH Installation
43. INSTALL REAR SEATBACK HINGE SUB-ASSEMBLY (for RH Side) Installation
44. INSTALL REAR DECK TRIM COVER Installation
45. INSTALL LUGGAGE COMPARTMENT TRAY Installation
46. INSTALL CHILD RESTRAINT SEAT TETHER ANCHOR Installation
47. INSTALL DECK FLOOR BOX RH Installation
48. INSTALL DECK FLOOR BOX LH Installation
49. INSTALL JACK ASSEMBLY Installation
50. INSTALL JACK CARRIER ASSEMBLY
51. INSTALL NO. 2 DECK BOARD Installation
52. INSTALL DECK BOARD ASSEMBLY Installation
53. INSTALL TONNEAU COVER ASSEMBLY (w/ Tonneau Cover)
54. INSTALL REAR SEATBACK ASSEMBLY RH Installation
55. INSTALL REAR SEATBACK INNER HINGE COVER (for RH Side) Installation
56. INSTALL REAR SEATBACK OUTER HINGE COVER (for RH Side) Removal
57. CONNECT REAR SEAT CENTER OUTER BELT ASSEMBLY Installation
58. INSTALL REAR SEAT CENTER HEADREST ASSEMBLY
59. INSTALL REAR SEAT HEADREST ASSEMBLY (for RH Side)
60. INSTALL REAR SEATBACK ASSEMBLY LH Installation
61. INSTALL REAR SEATBACK INNER HINGE COVER (for LH Side) Installation
62. INSTALL REAR SEATBACK OUTER HINGE COVER (for LH Side) Installation
63. INSTALL REAR SEAT HEADREST ASSEMBLY (for LH Side)
64. INSTALL REAR SEAT CUSHION ASSEMBLY Installation
65. INSTALL UPPER CENTER PILLAR GARNISH LH Installation
66. INSTALL LOWER CENTER PILLAR GARNISH LH Installation
67. CONNECT FRONT SEAT OUTER BELT ASSEMBLY LH Installation
68. INSTALL LAP BELT OUTER ANCHOR COVER (for Driver Side) Installation
69. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP LH Installation
70. INSTALL REAR DOOR SCUFF PLATE LH Installation
71. INSTALL UPPER CENTER PILLAR GARNISH RH Installation
72. CONNECT FRONT SEAT OUTER BELT ASSEMBLY RH Installation
73. INSTALL LOWER CENTER PILLAR GARNISH RH Installation
74. INSTALL LAP BELT OUTER ANCHOR COVER (for Front Passenger Side) Installation
75. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP RH Installation
76. INSTALL REAR DOOR SCUFF PLATE RH Installation
77. INSTALL UPPER INSTRUMENT PANEL SUB-ASSEMBLY Installation
78. CONNECT INSTRUMENT PANEL WIRE ASSEMBLY Installation
79. INSTALL NO. 1 INSTRUMENT PANEL BOX DOOR SUB-ASSEMBLY Installation
80. INSTALL GLOVE COMPARTMENT DOOR ASSEMBLY Installation
81. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY (for Manual Transaxle) Installation
82. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY (for Automatic Transaxle) Installation
83. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle) Installation
84. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for Automatic Transaxle) Installation
85. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL ASSEMBLY Installation
86. INSTALL FRONT PILLAR GARNISH LH (w/o Curtain Shield Airbag) Installation
87. INSTALL FRONT PILLAR GARNISH LH (w/ Curtain Shield Airbag) Installation
88. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP LH Installation
89. INSTALL COWL SIDE TRIM BOARD LH Installation
90. INSTALL FRONT DOOR SCUFF PLATE LH Installation
91. INSTALL FRONT PILLAR GARNISH RH (w/o Curtain Shield Airbag) Installation
92. INSTALL FRONT PILLAR GARNISH RH (w/ Curtain Shield Airbag) Installation
93. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP RH Installation
94. INSTALL COWL SIDE TRIM BOARD RH Installation
95. INSTALL FRONT DOOR SCUFF PLATE RH Installation
96. INSTALL COMBINATION METER ASSEMBLY Installation
97. INSTALL METER HOOD SUB-ASSEMBLY Installation
98. INSTALL INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY Installation
99. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY Installation
100. ADJUST SPIRAL CABLE Installation
101. INSTALL STEERING WHEEL ASSEMBLY Installation
102. INSTALL STEERING PAD Installation
103. INSTALL LOWER NO. 3 STEERING WHEEL COVER Installation
104. INSTALL LOWER NO. 2 STEERING WHEEL COVER Installation
105. INSPECT STEERING WHEEL CENTER POINT
106. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
107. INSPECT STEERING PAD Installation
108. INSPECT SRS WARNING LIGHT Diagnosis System
109. INSPECT SLIDING ROOF SYSTEM Programming and Relearning