DSD Information System
Home >> Toyota >> 2021 >> Highlander LE, 4WD >> Repair and Diagnosis >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Panoramic Moon Roof System - Diagnostics - Introduction >> Panoramic Moon Roof System >> Data List / Active Test [11/2023 - ] >> Data List / Active Test [11/2023 - ]

Data List / Active Test [11/2023 - ]

  1. DATA LIST 
    NOTE:

    In the following table, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    HINT: 

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    1. Read the Data List according to the display on the GTS.

      Body Electrical > Sliding Roof > Data List 

      Tester Display Measurement Item Range Normal Condition Diagnostic Note
      Front SW Auto Operation Sliding roof auto operation function OFF or ON Customize setting displayed -
      Hall IC1 Pulse Hall IC1 pulse output Lo or Hi Lo and Hi repeat during motor operation Lo: Hall IC1 output is low
      Hi: Hall IC1 output is high
      Hall IC1 Status Status of Hall IC1 Normal or Error Normal: Hall IC1 normal
      Error: Hall IC1 not normal      		 -
      Hall IC2 Pulse Hall IC2 pulse output Lo or Hi Lo and Hi repeat during motor operation Lo: Hall IC2 output is low
      Hi: Hall IC2 output is high
      Hall IC2 Status Status of Hall IC2 Normal or Error Normal: Hall IC2 normal
      Error: Hall IC2 not normal      		 -
      Ignition (Direct Signal) Ignition switch signal OFF or ON OFF: Ignition switch off
      ON: Ignition switch ON      		 -
      Ignition (MPX) Ignition switch signal (LIN signal) OFF or ON OFF: Ignition switch off
      ON: Ignition switch ON      		 -
      Door Courtesy Driver door courtesy light switch signal OFF or ON OFF: Driver door closed
      ON: Driver door open      		 -
      Key Off Permission Key-off sliding roof operation permit signal OFF or ON OFF: Any status except "ON" status
      ON: Front doors are not opened within 45 seconds after ignition switch turned off      		 -
      Vent Switch Sliding roof tilt switch signal OFF or ON OFF: Sliding roof switch not pressed
      ON: Sliding roof switch pressed      		 -
      Roof Open Switch Sliding roof open switch signal OFF or ON OFF: Sliding roof switch not slid backward
      ON: Sliding roof switch slid backward      		 -
      Roof Close Switch Sliding roof close switch signal OFF or ON OFF: Sliding roof switch not slid forward
      ON: Sliding roof switch slid forward      		 -
      Shade Close Switch Roof sunshade close switch signal OFF or ON OFF: Roof sunshade switch not slid forward
      ON: Roof sunshade switch slid forward      		 -
      Shade Open Switch Roof sunshade open switch signal OFF or ON OFF: Roof sunshade switch not slid backward
      ON: Roof sunshade switch slid backward      		 -
      Current Roof Open Switch Stuck ON Sliding roof open switch stuck signal (Current) OFF or ON OFF: No sliding roof switch stuck signal (Current)
      ON: Sliding roof switch stuck signal (Current)      		 -
      Current Roof Close Switch Stuck ON Sliding roof close switch stuck signal (Current) OFF or ON OFF: No sliding roof switch stuck signal (Current)
      ON: Sliding roof switch stuck signal (Current)      		 -
      Current Shade Close Switch Stuck ON Roof sunshade close switch stuck signal (Current) OFF or ON OFF: No roof sunshade switch stuck signal (Current)
      ON: Roof sunshade switch stuck signal (Current)      		 -
      Current Shade Open Switch Stuck ON Roof sunshade open switch stuck signal (Current) OFF or ON OFF: No roof sunshade switch stuck signal (Current)
      ON: Roof sunshade switch stuck signal (Current)      		 -
      Past Roof Open Switch Stuck ON Sliding roof open switch stuck signal (Past) OFF or ON OFF: No sliding roof switch stuck signal (Past)
      ON: Sliding roof switch stuck signal (Past)      		 -
      Past Roof Close Switch Stuck ON Sliding roof close switch stuck signal (Past) OFF or ON OFF: No sliding roof switch stuck signal (Past)
      ON: Sliding roof switch stuck signal (Past)      		 -
      Past Shade Close Switch Stuck ON Roof sunshade close switch stuck signal (Past) OFF or ON OFF: No roof sunshade switch stuck signal (Past)
      ON: Roof sunshade switch stuck signal (Past)      		 -
      Past Shade Open Switch Stuck ON Roof sunshade open switch stuck signal (Past) OFF or ON OFF: No roof sunshade switch stuck signal (Past)
      ON: Roof sunshade switch stuck signal (Past)      		 -
      Current Vent Switch Stuck ON Sliding roof tilt switch stuck signal (Current) OFF or ON OFF: No sliding roof switch stuck signal (Current)
      ON: Sliding roof switch stuck signal (Current)      		 -
      Past Vent Switch Stuck ON Sliding roof tilt switch stuck signal (Past) OFF or ON OFF: No sliding roof switch stuck signal (Past)
      ON: Sliding roof switch stuck signal (Past)      		 -
      Number of Trouble Codes Number of trouble codes Min.: 0 to Max.: 255 Number of DTCs is displayed -

      Body Electrical > Sliding Sunshade > Data List 

      Tester Display Measurement Item Range Normal Condition Diagnostic Note
      Hall IC1 Status Status of Hall IC1 Normal or Error Normal: Hall IC1 normal
      Error: Hall IC1 not normal      		 -
      Hall IC1 Pulse Hall IC1 pulse output Lo or Hi Lo and Hi repeat during motor operation Lo: Hall IC1 output is low
      Hi: Hall IC1 output is high
      Hall IC2 Status Status of Hall IC2 Normal or Error Normal: Hall IC2 normal
      Error: Hall IC2 not normal      		 -
      Hall IC2 Pulse Hall IC2 pulse output Lo or Hi Lo and Hi repeat during motor operation Lo: Hall IC2 output is low
      Hi: Hall IC2 output is high
      Ignition (MPX) Ignition switch signal (LIN signal) OFF or ON OFF: Ignition switch off
      ON: Ignition switch ON      		 -
      Ignition (Direct Signal) Ignition switch signal OFF or ON OFF: Ignition switch off
      ON: Ignition switch ON      		 -
      Key Off Permission Key-off sliding roof operation permit signal OFF or ON OFF: Any status except "ON" status
      ON: Front doors are not opened within 45 seconds after ignition switch turned off      		 Although this item is displayed on the GTS, it is not applicable to this vehicle.
      Vent Switch Sliding roof tilt switch signal OFF or ON OFF: Sliding roof switch not pressed
      ON: Sliding roof switch pressed      		 -
      Roof Open Switch Sliding roof open switch signal OFF or ON OFF: Sliding roof switch not slide backward
      ON: Sliding roof switch slide backward      		 -
      Roof Close Switch Sliding roof close switch signal OFF or ON OFF: Sliding roof switch not slide forward
      ON: Sliding roof switch slide forward      		 -
      Shade Close Switch Roof sunshade close switch signal OFF or ON OFF: Roof sunshade switch not slide forward
      ON: Roof sunshade switch slide forward      		 -
      Shade Open Switch Roof sunshade open switch signal OFF or ON OFF: Roof sunshade switch not slide backward
      ON: Roof sunshade switch slide backward      		 -
      Current Roof Open Switch Stuck ON Sliding roof open switch stuck signal (Current) OFF or ON OFF: No sliding roof switch stuck signal (Current)
      ON: Sliding roof switch stuck signal (Current)      		 -
      Current Roof Close Switch Stuck ON Sliding roof close switch stuck signal (Current) OFF or ON OFF: No sliding roof switch stuck signal (Current)
      ON: Sliding roof switch stuck signal (Current)      		 -
      Current Shade Close Switch Stuck ON Roof sunshade close switch stuck signal (Current) OFF or ON OFF: No roof sunshade switch stuck signal (Current)
      ON: Roof sunshade switch stuck signal (Current)      		 -
      Current Shade Open Switch Stuck ON Roof sunshade open switch stuck signal (Current) OFF or ON OFF: No roof sunshade switch stuck signal (Current)
      ON: Roof sunshade switch stuck signal (Current)      		 -
      Past Roof Open Switch Stuck ON Sliding roof open switch stuck signal (Past) OFF or ON OFF: No sliding roof switch stuck signal (Past)
      ON: Sliding roof switch stuck signal (Past)      		 -
      Past Roof Close Switch Stuck ON Sliding roof close switch stuck signal (Past) OFF or ON OFF: No sliding roof switch stuck signal (Past)
      ON: Sliding roof switch stuck signal (Past)      		 -
      Past Shade Close Switch Stuck ON Roof sunshade close switch stuck signal (Past) OFF or ON OFF: No roof sunshade switch stuck signal (Past)
      ON: Roof sunshade switch stuck signal (Past)      		 -
      Past Shade Open Switch Stuck ON Roof sunshade open switch stuck signal (Past) OFF or ON OFF: No roof sunshade switch stuck signal (Past)
      ON: Roof sunshade switch stuck signal (Past)      		 -
      Current Vent Switch Stuck ON Sliding roof tilt switch stuck signal (Current) OFF or ON OFF: No sliding roof switch stuck signal (Current)
      ON: Sliding roof switch stuck signal (Current)      		 -
      Past Vent Switch Stuck ON Sliding roof tilt switch stuck signal (Past) OFF or ON OFF: No sliding roof switch stuck signal (Past)
      ON: Sliding roof switch stuck signal (Past)      		 -
      Number of Trouble Codes Number of trouble codes Min.: 0 to Max.: 255 Number of DTCs is displayed -

      Body Electrical > Main Body > Data List 

      Tester Display Measurement Item Range Normal Condition Diagnostic Note
      FR Door Courtesy Switch Status Front door courtesy light switch (RH) signal Close or Open Close: Front door RH closed
      Open: Front door RH open      		 -
      FL Door Courtesy Switch Status Front door courtesy light switch (LH) signal Close or Open Close: Front door LH closed
      Open: Front door LH open      		 -
      IGR Power Ignition switch ON signal OFF or ON OFF: Ignition switch off or ACC
      ON: Ignition switch ON      		 -
      Communication Sunshade ECU Connection status between roof sunshade ECU (sliding roof drive gear assembly) and main body ECU (multiplex network body ECU) STOP or OK STOP: Communication stopped
      OK: Normal communication      		 -
      Communication Slide Roof Connection status between sliding roof ECU (sliding roof drive gear assembly) and main body ECU (multiplex network body ECU) STOP or OK STOP: Communication stopped
      OK: Normal communication      		 -
      Slide Roof Open Warning Function Sliding roof open warning function OFF or ON Customize setting displayed -
  2. ACTIVE TEST 

    HINT: 

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

    1. Perform the Active Test according to the display on the GTS.

      Body Electrical > Sliding Roof > Active Test 

      Tester Display Measurement Item Control Range Diagnostic Note
      Slide Roof Operate sliding roof motor OFF / Opn/Dwn / Clos/Up -

      Body Electrical > Sliding Sunshade > Active Test 

      Tester Display Measurement Item Control Range Diagnostic Note
      Sliding Sunshade Operate roof sunshade OFF / Open / Close -
Diesel-Data.com